Volden Rapid set Concrete, 5kg Tub - Requires mixing before use

Product information

Volden Rapid set concrete is ideal for emergency repairs, paths, steps, shed bases and flooring. Pre-mixed and ready to use, just add clean water. Sets within 30 minutes

• Guarantee - Statutory
• Resistant to chemicals, frost & water
• Requires mixing before use
• The area to be worked should be free from oil, grease and loose material. Do not use at temperatures below 5°C or above 30°C without taking precautions to ensure that new work is protected from freezing or drying-out. NOTE: This product is pre-blended and requires no further mixing before adding water. 1) Open bucket, removing dry Volden Rapid Set Concrete mix bag. Dependent on required volume of concrete, fill plastic tub with clean water to required level using internal water mark indicators. NOTE: Refer to mix ratio table for details on expected consumption. 2) Empty contents of bag and mix thoroughly until the desired consistency is achieved. 3) If mixing in the tub, add 0.5 litres of clean water per 5 kg bag of concrete. For smaller quantities, mix 12 parts dry concrete mix with 1 part clean water. Always mix thoroughly. 4) Clean the area to which the product will be applied. Once mixed evenly, place the concrete into the area and compact. Finish with brush, trowel or float. 5) Volden Rapid Set Concrete should be used within 30 minutes of adding water. Concrete should be fully compacted before finishing. Newly finished concrete should be protected from drying out by covering with polythene sheeting or wet hessian (sacking) for a minimum of 7 days. The final strength and finish of this product will depend on the user having the required skills and familiarity with the product and its application methods. 6) Clean all tools and equipment immediately after use, before the material has set.
• Danger Causes serious eye damage. Causes skin irritation. May cause an alergic reaction. May cause respiratory irritation. Keep out of reach of children. Wear protective gloves/protective clothing/eye protection/face protection. : Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do Continue rinsing. Immediately call a doctor/physician. Wash with plenty of soap and water. If skin irritation or rash occurs: Get medical advice/attention. Avoid breathing dust/fume/gas/mist/vapours/spray. IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing. Call a doctor/physician if you feel unwell. Dispose of contents/container to: Harden by application of water and dispose of as concrete waste. Refer to product SDS

Features and benefits

• For small concrete repairs to paths, steps and general repairs
• Easy to use water fill markings inside the tub
• Ready to use, just add water and mix in the tub
• Initial set within 30 minutes